Li-V is Specially designed lithium battery for vehicles(Electric Vehicles). Now a days demand for fossil fuel is high and in future it will be much higher, But since they are totally dependent on nonrenewable energy sources, Their end is fixed, To stop/reduce this a step should be taken, otherwise it would be too late, And A STEP IS HERE AT VISION MECHATRONICS. We have introduced a special lithium battery for Electric vehicles to reduce pollution as well as reduce burden on the eco system by green house gas emission.Li-V lithium battery for vehicles is based on the active cell balancing technology for best performance and life expectancy, and remote monitoring via internet.
The life expectancy of Li-V lithium battery for vehicles is 13.5 years* which is very high as compared to the other systems present in the market. We offer 60 Ah /48 V battery. It is absolutely maintenance free. It has internet ready systems, allows user to monitor it remotely. The chemical composition is intrinsically safe in their chemistry, that is to say, they can neither burn nor explode.
Li-V lithium batteries for vehicles are a good substitute for diesel/petrol or gasoline and A step towards supporting Eco Friendly energy, to make Clean & Green India.
Due to their physicochemical properties lithium cells call for a battery management system (BMS), to maximize cell capacity and to equalize the cells voltage levels. Most available BMS for Lithium batteries for vehicles realize passive balancing for it. Excessive energy from single fully charged cells will be wasted as heat, while other cells still get charged. For this reason passive balancing yields an efficiency of 0%! Over the years of operation the single cells characteristics drift apart. A chain is only as strong as its weakest link - the same applies to a combination of cells: the weakest cell is responsible for decreasing battery capacity. So much for the state of the art... to get 10% more mileage!!!
And now the future comes home! Our in-house developed BMS Lithium Battery for Vehicles Li-V utilizes active balancing. The states of charge of a battery's cells are being equalized continuously among one another. That is to say, energy from higher charged cells will be transferred to lower charged ones. This results in 90% efficiency, compared to 0% with passive balancing. Additionally, active balancing increases life expectance of Li-cells by more than 30% due to reduced drift of characteristics. Increased energy yield from the charged battery is another positive side effect: with passive balancing the depth of discharge (DoD) should not exceed 70% to provide long life expectancy of the battery. Our active balancing allows for 100% DoD without reduced life expectancy - thus 14% more energy with identical rated capacity.
Li-V our lithium battery for vehicles also enables communication of the battery with the inverter via CAN interface, as well as internet based remote monitoring of the battery independently. In this process all relevant data like voltage, state of charge, temperature etc. will be logged and analyzed for each battery on single cell level. For instance, this allows for identification of an early seasoned cell of a battery, and arrange for its prophylactic replacement. Thus, a possible system failure can be avoided.
Regarding the lithium cells we also stand out from the usual market standard - lithium-iron phosphate (LiFePO4). Instead, we use lithium iron Manganese phosphate (LiFeMnPO4). The doping with Manganese will increase the cell's life expectancy and performance. The conceptual design and chemistry of our Li-cells renders them intrinsically safe, this means in case of a problem the cells can not catch fire. By the way, most cell phone or laptop batteries are not intrinsically safe! Lithium cells are almost completely recyclable. And - in contrast to lead batteries - they do not contain any hazardous material.
Yes we will buy back the used Lithium Battery for Vehicles "Li-V" batteries.Please contact us for evaluation & buy back value.
|Parameter||Lead Acid Battery||Li-V|
|Efficiency||Low about 60%||As high as 95%|
|Weight||Bulky/ Heavy Weight||Lighter Weight|
|Space Requirements||Large Space||very handy|
|Life Cycle||Lesser Life Cycle||13.5 Years life* (5000 cycles*)|
|Vested Interest||Yes (Lead Theft Possible)||No vested interest|
|Repairs||Frequent Replacement||Long Life|
|Remote Monitoring||X||Remote Monitoring Possible|
|Operating Temperature||25°C to 35°C||-25°C to +50°C [-13F to 122F]|
|BMS SUPPORT||-||Active balancer,Relay Trigger,Single Cell Monitoring|
|Charging Time||Long Charging Time (Min 8Hrs)||Shorter Charging Time (0.5 / 1/ 2/ 3 Hrs)|
|Plug & Play Ability||-||Yes|
|OTA Support||-||Yes (Firmware Upgrades Over The Air)|
|BMS||Active Balancer,Relay Trigger,single cell monitoring||Active Balancer,Relay Trigger,single cell monitoring|
|Dimensions(WxHxD)||470x380x240mm(Stain less steel casing)||600x370x240 mm(Stain less steel casing)|
|Weight||47 kg (103 lbs)||65 kg (143 lbs*)|
|Dod||max. 100%||max. 100%|
|Operating Temperature||-25°C to +50°C [-13F to 122F]||-25°C to +50°C [-13F to 122F]|
Yes, Li-V is absolutely maintenance free, you don’t have to add any sort of battery water or clean the terminals.
A charge cycle is the process of charging a rechargeable battery and discharging it as required into a load.
Yes Li-V is absolutely safe to install in vehicles and is non-flammable as well as non-explosive.
No, You can leave the Li-V unused to a period up to 3 months safely, the battery charge or condition will not deteriorate.
Yes, Li-V comes with inbuilt protections like over voltage, under voltage, over current, under currents, fault detection. The system automatically disconnects in case of any faults so that all your appliances, home, shops, industry is absolutely safe.
Li-V is the first Internet Ready battery which comes with a remote monitoring feature which helps you know the health of the battery, state of charge and many other parameters. Also gives a warning on faults!
Li-V can be charged by solar power, wind power, grid, and/or any dc source of the appropriate ratings.
Yes, custom size are available on special requests, you can write to us on firstname.lastname@example.org
Li-V can be fully charged in 0.5/1/2/3 hours depending upon Charger used for charging the battery.
Yes, Li-V is programmable to suit your requirements.
No, Li-V does not emit any fumes or pollutants, it is completely eco-friendly.
No, You will never have to add battery water to Li-V.
Yes, Li-V is recyclable and has a buy back value.
Yes, Li-V can sustain Indian weather conditions. It can operate in temperatures from -25°C to +50°C.
The life expectancy of Li-V is 13.5 years* (5000 cycles @ 100% DoD), so install Li-V and forget replacement headache for the next 13.5 years*.